After the engine of the mixing truck is started, the mixing drum should be allowed to run at low speed for about 10 minutes to raise the hydraulic oil temperature to above 20 ℃ before starting operation.

攪拌車裝料前應將攪拌筒反轉，保證倉斗內的積水和雜物排出，這樣可以確?；炷恋馁|量，保證施工質量。

Before loading the mixer truck, the mixing drum should be reversed to ensure the discharge of accumulated water and debris from the hopper, which can ensure the quality of concrete and construction.

攪拌車在運輸混凝土時，要保證滑斗放置牢固，防止因松動造成擺動，在行進中打傷行人或影響其它車輛正常運行。在運輸過程中，平坦路面上攪拌筒轉速保證在2-3轉/分，行駛在側傾坡度大于50的路面，或左右晃動較大的路面時，應停止攪拌旋轉，待路況好轉后再恢復攪拌旋轉。

When transporting concrete, the mixer truck should ensure that the sliding bucket is firmly placed to prevent swinging caused by looseness, which may cause injuries to pedestrians or affect the normal operation of other vehicles. During transportation, the speed of the mixing drum should be ensured to be 2-3 revolutions per minute on a flat road surface. When driving on a road surface with a side slope greater than 50 or a road surface with significant left and right shaking, the mixing rotation should be stopped and resumed after the road conditions improve.

混凝土攪拌車運送混凝土的時間不能超過攪拌站規定的時間。運送混凝土途中，攪拌筒不得長時間停轉，以防混凝土產生離析現象。司機應時常觀察混凝土情況，發現異常及時通報調度室，申請做出處理。

The time for transporting concrete by concrete mixer trucks cannot exceed the time specified by the mixing station. During the transportation of concrete, the mixing drum should not be stopped for a long time to prevent segregation of the concrete. Drivers should regularly observe the concrete condition, promptly report any abnormalities to the control room, and apply for handling.

攪拌罐車裝有混凝土時，在現場停滯時間不得超過1小時，如超時應立即要求現場負責人給予及時處理。

When the mixing tank truck is loaded with concrete, the standing time on site shall not exceed 1 hour. If it exceeds the time limit, the on-site person in charge shall be immediately requested to provide timely treatment.

攪拌車運送混凝土塌落度不得低于8cm。從混凝土入罐到排出，氣溫高時不得超過2小時必須排出，陰雨天氣溫度低時，不得超過2.5小時。

The slump of concrete transported by mixer trucks shall not be less than 8cm. From the pouring of concrete into the tank to the discharge, it must not exceed 2 hours when the temperature is high, and it must not exceed 2.5 hours when the temperature is low in rainy weather.

攪拌車在排出混凝土之前，應使攪拌筒在10-12轉/分的轉速下轉動1分鐘，再進行排料。

Before discharging concrete, the mixing truck should rotate the mixing drum at a speed of 10-12 revolutions per minute for 1 minute before discharging.

混凝土攪拌車出料完畢，應立即用隨車的軟管放水將進料口、出料斗及出料溜槽等部位沖洗干凈，排去粘結在車身各處的污物及殘留混凝土，再向攪拌筒內注水150-200L的清水，在返回途中要讓攪拌筒慢速轉動，以清洗內壁，避免殘余料渣附在筒壁和攪拌葉上，并在再一次裝料前將這些水放掉。

After the discharge of the concrete mixer truck is completed, the inlet, discharge hopper, and discharge chute should be immediately rinsed with water from the accompanying hose to remove any dirt and residual concrete adhering to the vehicle body. Then, 150-200L of clean water should be injected into the mixing drum. On the way back, the mixing drum should be slowly rotated to clean the inner wall and prevent residual slag from adhering to the drum wall and mixing blades. This water should be drained before loading again.

混凝土攪拌車運送混凝土時，發動機轉速在1000-1400轉/分范圍內工作，以使發動機有大扭距，在運送混凝土過程中，車速不得超過40km/h，以保行車安全。

When transporting concrete with a concrete mixer truck, the engine speed should be within the range of 1000-1400 rpm to ensure maximum torque. During the transportation of concrete, the speed should not exceed 40km/h to ensure driving safety.

水泥攪拌車工作完畢，應把攪拌筒內部和車身清洗干凈，不能使剩余的混凝土留在筒內。

After the cement mixer truck is completed, the inside of the mixing drum and the vehicle body should be cleaned thoroughly, and the remaining concrete should not be left inside the drum.

水泥攪拌車在水泵工作時，禁止空轉，連續使用時不要超過15分鐘。

When the cement mixer truck is working with the water pump, it is prohibited to idle and should not exceed 15 minutes of continuous use.

混凝土攪拌車水箱的水量要經常保持裝滿，以備急用，冬季停機后，應將水箱、水泵、水管、攪拌筒內的水放凈，并停放在朝陽、不積水的地方，以免凍壞機械。

The water volume in the water tank of the concrete mixer truck should be regularly kept full for emergency use. After stopping in winter, the water tank, water pump, water pipe, and mixing drum should be drained and parked in a sunny and non stagnant area to avoid freezing and damaging the machinery.

攪拌車在冬季應及時安裝保溫套，并使用防凍液對攪拌車加以保護，根據天氣變化更換燃油標號，確保機械的正常使用。

The mixing truck should be promptly installed with insulation sleeves in winter, and protected with antifreeze. The fuel label should be changed according to weather changes to ensure the normal use of the machinery.

在檢查、修理水泥攪拌車液壓傳動部分時，應使發動機和液壓泵在沒有壓力的情況下進行。

When inspecting and repairing the hydraulic transmission part of the cement mixer truck, the engine and hydraulic pump should be operated without pressure.

在調整中科攪拌車各部間隙、行程、壓力時，應由專職安全員檢查同意;更換機件時，必須由部長或主管經理簽字，否則出現問題后追究有關人員責任

When adjusting the clearance, stroke, and pressure of each part of the Zhongke mixing truck, it should be checked and approved by a full-time safety officer; When replacing machine parts, it must be signed by the minister or manager in charge, otherwise the relevant personnel will be held responsible after any problems occur